List updated as of 02/21/2022
Green = parts already purchased
Maintenance
Fluids
- Brake fluid: Flush next year (half way through two year cycle). Continue to use 1L ATE SL6-1.
- Transmission fluid: Replace in 30k miles. Currently Redline D4 ATF, but will try either Ravenol 75W-80 stuff per this thread or BMW's transmission oil (83222339219)
- Differential fluid: Replace in 30k miles. Currently Red Line 75W-90 GL5
- Power steering fluid: Overdue by a few thousand miles (30k interval) and about one year overdue for flush (five year interval). Continue to use ATF. See below regarding power steering lines.*
Mechanical items
- Power steering lines: Leak noted previously by my mechanic. Relatively sure it's the feed line (32416774215[?]), but may also be the return hose (32416796390) or suction hose (32416750155). Should also just assess if other lines/components need to be replaced.*
- Replace lower coolant hose (11531436408) at next coolant flush (82141467704) next year.
- Replace leaking oil filter housing gasket (OFHG, 11421719855): Purchased BavAuto Viton version from ECS here, since BavAuto was absorbed by ECS. Will use this guide.
- Replace soft fuel lines to/from fuel filter.
- Replace differential bushings: One of them (unclear which) was found to be cracked by BMW dealership during complementary inspection. Will purchase OEM rubber parts (front: 33176770788, rear: 33176751808).
- Adjust upper (13541438761) and lower intake boots (13541438759): Replaced when installing ZHPizza's large bore throttle body, but don't seem perfectly aligned (some bend in the upper intake boot).
- Replace AC blower: Although squeaking/fluttering sound has improved, will at some point need to replace the AC blower motor
- Replace driveshaft guibo/flexdisc (26117511454) and the center support bearing (26127501257). DIY guide here.
Exterior
- Repair cracked/dying rear window gaskets using this guide
- Replace or renew fading side markers
Miscellaneous
- Replace spare tire: I believe mine is original and should be replaced (I think it is T125/80R17)
- Get alignment following Bimmerworld spherical RTAB installation (see below)***
Modifications
Suspension
- Install Bimmerworld Spherical RTABs.***
- Install 330Cic or Xi rear sway bar (33556751267) w/ correct bushings (33551096669)
Engine/drivetrain:
- Install M3 fuel baffle (16112229656)
- Install M3 motor mounts (11812283798 [2x])
- Purchase/install LSD of some sort with 3.23 or 3.38 ratio
- Purchase/install the M56 valve cover per this thread or purchase German Auto Solutions CCV Replacement Kit
- Fabricate/install custom brake duct air scoop: Using this guide
Electronics
- Recode the car as a convertible to have one touch up/down windows: Using this guide. Would also require new center console trim and window switch (61316902183)
- Install M3 gauge cluster if someone can figure out coding the shift lights for a manual, non-M car.
- Install Bavsound Stage 1 speaker kit
Interior
- Repaint the Black Cube Trim to Silver Cube trim: Using this "guide" and Precision Grey paint from Advance Auto.
- Fix lower steering wheel trim through this guy
- Install the euro tray (51167038323)
- Consider ID4Motion's digital cluster
Exterior
- Purchase/paint brake calipers black using G2 kit
- Install used OEM Shark Fin