Materials to Maintain Your ZHP IIIII Hand Protection IIIII Tools to Maintain Your ZHP
Page 1 of 2 12 LastLast
Results 1 to 10 of 19
  1. #1
    Join Date
    Jan 1970
    Location
    Liberty Township, OH
    Posts
    37,935

    2004 Imola ZHP - 270K Miles

    Have been troubleshooting numerous codes. Replaced fuel filter (found intake to fuel pressure regulator broken) , spark plugs (found oil on threads, wells dry), and CCV system rebuild to include:
    - Oil dip stick tube to pan o-ring QTY 1
    - Oil dip stick o-rings QTY 2
    - Intake air distribution manifold o-rings QTY 6
    - CCV Oil seperator
    - CCV Drain hose from separator
    - CCV drain hose from vanos
    - CCV drain hose from air distribution manifold QTY 2

    Long story short.... Upon fire up, car was running very much the same. Cleared codes, took car for a drive. Good power, car running a bit rough (misfire), and as I pulled into driveway, I noticed a whidp of smoke from engine bay.

    Popped hood, and this is what I found....

    Oil on this mount....




    This plug installed, right below spark plug #2 on head....


    This plug missing. Located right under spark plug #4, on side of head. What is this plug, what is the nomenclature, and what realoem drawing is it on?





    Thanks for any help.

    Sent from my Note 9 using Tapatalk
    Call Me Dane l 2/2004 330i ZHP l 18x8 ET45 BBS CK's wrapped with Michelin Pilot Sport AS3+ @ 245-40-18 l KW V1 Coilovers in front l KW V1 springs w/ Bilstein B8 dampeners in rear l BMW Performance Rotors l UUC StrutBarbarian l Racing Dynamics Rear Strut Bar l Jim Conforti Shark Injector l Light Birch Interior Trim l Bimmian Celly Mount l M3 Trunk Mat l l e90 Performance E-Brake & Shift Knob l M3 Tri-Stitched Boots l AL Headlight Retrofit with ZKW Lenses l CobyWheel Wrap w/M3 Stitching l LCM sw 4.5 triple blink and rear fogs l Maple Interior Trim

  2. #2
    Join Date
    Mar 2011
    Location
    Independence KY
    Posts
    2,832
    I can’t be of any help, but am equally curious. Wondering why that would be missing or back out AND what it’s purpose is
    2005 BMW 330i ZHP - BMWP brakes/intake/strut bar/shifter, Coby wraps interior, BBS CHs, Eagle Eye LED tails, LED fog lights, GC coilovers, Sprint Booster/sport button mod, 4.5 LCM w/ programming, Xtrons 9inch HU, BSW stg1, dynamat, M3 sedan dead pedal, oCarbon CF interior trim, CF seat backs, 2x2 CF MTECH2 diffuser, CF cabin filter cover



  3. #3
    Join Date
    Jan 1970
    Location
    Southern California
    Posts
    18,064
    Quite a bit of stuff, sux you're still having the issue. Good luck sorting it out I'm not sure what that is.

    Sent from my SM-G988U using Tapatalk
    Randeaux/Rando/John/jr - '06 Cic ZHP; Southern California
    "ZHP or not, I still like you"


    ZHP Performance Package, Cold Weather Package, Leather, Jet Black/Black/BlackCube, NAV, Anthracite Black "my individual" interior trim
    ESS Stage 1 Twin Screw Supercharger, Sprint Booster, BMW Perf Intake, Magnaflow Exhaust, Dinan TB & STEP S/W, UCC Sway Bars, Apex EC-7 18x8.5 ET38
    Suspension: AST 44100 dampers, Bimmerworld front adjustable end links, Swift springs (8K front, 10K rear), Vorshlag camber plates
    Dynavin D99+, Hardwire V1 (w/V1 Connection), BSW Stage 1 Speakers, Kicker Amp/Subwoofer
    BMW Performance Strut Brace, Orion V2 Angel Eyes, No-holes License Plate, SMG Paddle Shift Mod, Besian VANOS, Gold DISA, Fan Delete, M3 Side Mirrors
    Note: Actual car no longer resembles signature picture

  4. #4
    Join Date
    Jan 1970
    Location
    Liberty Township, OH
    Posts
    37,935
    I'm going to pick up peice 14 and 15 and see how it goes....

    Sent from my Note 9 using Tapatalk
    Call Me Dane l 2/2004 330i ZHP l 18x8 ET45 BBS CK's wrapped with Michelin Pilot Sport AS3+ @ 245-40-18 l KW V1 Coilovers in front l KW V1 springs w/ Bilstein B8 dampeners in rear l BMW Performance Rotors l UUC StrutBarbarian l Racing Dynamics Rear Strut Bar l Jim Conforti Shark Injector l Light Birch Interior Trim l Bimmian Celly Mount l M3 Trunk Mat l l e90 Performance E-Brake & Shift Knob l M3 Tri-Stitched Boots l AL Headlight Retrofit with ZKW Lenses l CobyWheel Wrap w/M3 Stitching l LCM sw 4.5 triple blink and rear fogs l Maple Interior Trim

  5. #5
    Join Date
    Nov 2017
    Location
    Irvine, CA
    Posts
    818
    Bummer about the leak. I think the leak is coming from a missing blind plug in the head. There are a series of them along the exhaust side of the head. That screw plug (#14 from REALOEM diagram) is between cylinder 3 and 4, and there is a blind plug over each cylinder.




    The screw plug, part #14, is on the right, and the blind plug over cylinder 4 is on the left.



    I think what's missing is something like this engine block blind plug (link):



    Maybe a local engine machine shop can help with its replacement.

    Edit: In case you need it, I measured the diameter of the blind plug:10.0 mm.

  6. #6
    Join Date
    Jan 1970
    Location
    Liberty Township, OH
    Posts
    37,935
    Goddamn piece 27 on the below!

    https://www.realoem.com/bmw/enUS/sho...diagId=11_2213



    Sent from my Note 9 using Tapatalk
    Call Me Dane l 2/2004 330i ZHP l 18x8 ET45 BBS CK's wrapped with Michelin Pilot Sport AS3+ @ 245-40-18 l KW V1 Coilovers in front l KW V1 springs w/ Bilstein B8 dampeners in rear l BMW Performance Rotors l UUC StrutBarbarian l Racing Dynamics Rear Strut Bar l Jim Conforti Shark Injector l Light Birch Interior Trim l Bimmian Celly Mount l M3 Trunk Mat l l e90 Performance E-Brake & Shift Knob l M3 Tri-Stitched Boots l AL Headlight Retrofit with ZKW Lenses l CobyWheel Wrap w/M3 Stitching l LCM sw 4.5 triple blink and rear fogs l Maple Interior Trim

  7. #7
    Join Date
    Nov 2017
    Location
    Irvine, CA
    Posts
    818

  8. #8
    Join Date
    Jan 1970
    Location
    Liberty Township, OH
    Posts
    37,935
    This lil john

    Sent from my Note 9 using Tapatalk
    Call Me Dane l 2/2004 330i ZHP l 18x8 ET45 BBS CK's wrapped with Michelin Pilot Sport AS3+ @ 245-40-18 l KW V1 Coilovers in front l KW V1 springs w/ Bilstein B8 dampeners in rear l BMW Performance Rotors l UUC StrutBarbarian l Racing Dynamics Rear Strut Bar l Jim Conforti Shark Injector l Light Birch Interior Trim l Bimmian Celly Mount l M3 Trunk Mat l l e90 Performance E-Brake & Shift Knob l M3 Tri-Stitched Boots l AL Headlight Retrofit with ZKW Lenses l CobyWheel Wrap w/M3 Stitching l LCM sw 4.5 triple blink and rear fogs l Maple Interior Trim

  9. #9
    Join Date
    Jan 1970
    Location
    Liberty Township, OH
    Posts
    37,935
    Can't find it anywhere to ship earlier than 8/17. Ugh

    Sent from my Note 9 using Tapatalk
    Call Me Dane l 2/2004 330i ZHP l 18x8 ET45 BBS CK's wrapped with Michelin Pilot Sport AS3+ @ 245-40-18 l KW V1 Coilovers in front l KW V1 springs w/ Bilstein B8 dampeners in rear l BMW Performance Rotors l UUC StrutBarbarian l Racing Dynamics Rear Strut Bar l Jim Conforti Shark Injector l Light Birch Interior Trim l Bimmian Celly Mount l M3 Trunk Mat l l e90 Performance E-Brake & Shift Knob l M3 Tri-Stitched Boots l AL Headlight Retrofit with ZKW Lenses l CobyWheel Wrap w/M3 Stitching l LCM sw 4.5 triple blink and rear fogs l Maple Interior Trim

  10. #10
    Join Date
    Nov 2017
    Location
    Irvine, CA
    Posts
    818
    Not even a dealer? If the BMW Parts Distribution Centers (there's 6 in the US, I believe) have it in stock then it should be 2-3 days max for them to get it. But if they don't, then it'll have to come from supplier / Europe.

Page 1 of 2 12 LastLast

Similar Threads

  1. 2004 BMW ZHP Sedan - Imola Red / 6MT with 28K miles - $28K (EAG)
    By NYRhockey in forum BMW 330 ZHPs For Sale (vehicles only)
    Replies: 29
    Last Post: 11-29-2016, 11:40 AM
  2. 2004 Imola/ Alcantara ZHP 51K miles Auto
    By [USMC]Skywalker in forum BMW 330 ZHPs For Sale (vehicles only)
    Replies: 32
    Last Post: 02-05-2016, 08:28 AM
  3. Imola Red 2004 BMW 330i ZHP, AT w/ 80k miles (Houston) - $9,000
    By BMWCurves in forum BMW 330 ZHPs For Sale (vehicles only)
    Replies: 1
    Last Post: 11-17-2014, 04:46 PM
  4. FS: 2004 BMW 330i, Imola/Blk, AT, 74,500 Miles - $12,850, Houston, TX
    By ELCID86 in forum BMW 330 ZHPs For Sale (vehicles only)
    Replies: 1
    Last Post: 04-08-2013, 11:44 AM
  5. FS: 2004 Imola Red 330CI ZHP 111k miles (6-Spd), $10,500, NC
    By ELCID86 in forum BMW 330 ZHPs For Sale (vehicles only)
    Replies: 4
    Last Post: 02-21-2013, 02:01 PM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •